Sains Malaysiana 47(1)(2018): 181–187

http://dx.doi.org/10.17576/jsm-2018-4701-21

Enhancement of Thermoelectric Properties of Yb_0.25Co₄Sb₁₂ Skutterudites through Ni Substitution

(Peningkatan Sifat Termoelektrik bagi Bahan Skuterudit Yb_0.25Co₄Sb₁₂ melalui Penggantian Ni)

MOHAMED BASHIR ALI BASHIR¹, SUHANA MOHD SAID^2*, MOHD FAIZUL MOHD SABRI², YUZURU MIYAZAKI³, DHAFER ABDUL AMEER SHNAWAH², MASANORI SHIMADA³ & MOHAMED HAMID ELSHEIKH⁴

¹Department of Mechanical Engineering, Faculty of Engineering, Eldaein University, 63312 Eldaein, Sudan

²University of Malaya, 50603 Kuala Lumpur, Federal Territory, Malaysia

³Tohoku University, 2 Chome-1-1 Katahira, Aoba Ward, Sendai, Miyagi Prefecture 980-8577, Japan

⁴R&D, Cree Inc., Durham, NC 27703, USA

Diserahkan: 28 November 2016/Diterima: 9 Jun 2017

ABSTRACT

In this work, we investigate the effects of Ni doping on the thermoelectric (TE) properties of Yb_0.25Co₄Sb₁₂ sample. Yb_0.25Co_4-xN_ixSb₁₂ (0 ≤ x ≤ 0.5) samples were prepared by mechanical alloying and subsequently consolidated by spark plasma sintering. The morphology of consolidated samples were characterized by X-ray diffraction (XRD) and scanning electron microscopy and energy-dispersive X-ray spectroscopy (SEM-EDS). The thermoelectric properties of bulk samples were measured from room temperature to 800 K. The XRD analysis confirmed that, the successful formation of the Co₄Sb₁₂ skutterudite phase and Ni is substituted into Co site of the skutterudite crystal lattice. Moreover, the electrical resistivity decreased to 14.6 μΩm at 785 K for Yb_0.25Co_3.5Ni_0.5Sb₁₂ sample, due to increase of the electron concentration by Ni-addition. The absolute Seebeck coefficient reached the highest value of 223 μV/K at 592 K for Yb_0.25Co_3.7Ni_0.3Sb₁₂ sample, thus yielding a maximum value of power factor of 2.41 × 10_-3 W/mK₂ at 592 K. The highest dimensionless thermoelectric figure of merit value ZT of 0.49 at 692 K has been achieved for the Yb_0.25Co_3.7Ni_0.3Sb₁₂ sample, compared to ZT=0.06 for the Yb_0.25Co₄Sb₁₂ sample at same temperature. This work indicates a strategy to improve the thermoelectric performance by Ni substitution of Co sites in the Yb_0.25Co₄Sb₁₂ skutterudite through simultaneous improvement of its electrical conductivity, Seebeck coefficient and reduction of its thermal conductivity.

Keywords: Mechanical alloying; Ni-doping; skutterudite; thermoelectric

ABSTRAK

Dalam kajian ini, kesan pendopan Ni ke atas sifat Yb_0.25Co₄Sb₁₂ telah dikaji. Sampel Yb_0.25Co_4-xNixSb₁₂ (0 ≤ x ≤ 0.5) telah disediakan dengan kaedah pengaloian mekanikal dan seterusnya digabungkan dengan pensinteran pencucuh plasma. Morfologi untuk sampel gabungan telah dicirikan oleh pembelauan sinar-X (XRD) dan imbasan mikroskop elektron berserta tenaga serakan X-ray spektroskopi (SEM-EDS). Ciri termoelektrik sampel telah diukur daripada suhu bilik ke 800 K. Analisis XRD mengesahkan bahawa Ni berjaya didopkan ke dalam Yb_0.25Co_4-xN_ixSb₁₂ CoSb₃ dalam fasa skutterudite, dengan Ni menggantikan beberapa lokasi Co dalam kekisi kristal skuterudit. Selain itu, kerintangan elektrik menurun kepada 14.6 μΩm di 785 K bagi sampel Yb_0.25Co_3.5Ni_0.5Sb₁₂, disebabkan oleh peningkatan bilangan pembawa cas elektron oleh Ni. Pekali Seebeck mutlak mencapai nilai tertinggi 223 μV/K pada 592 K bagi sampel Yb_0.25Co_3.7Ni_0.3Sb₁₂ , lalu menghasilkan nilai maksimum faktor kuasa 2.41 × 10_-3 W/MK2 pada 592 K. Angka merit, ZT yang optimum adalah 0.49 pada 692 K telah dicapai untuk sampel Yb_0.25Co_3.7Ni_0.3Sb₁₂. Kajian ini menunjukkan strategi untuk meningkatkan prestasi termoelektrik melalui penggantian Ni pada bahagian Co dalam bahan skutterudite Yb_0.25Co₄Sb₁₂, sekaligus menambahbaik kekonduksian elektrik, pekali Seebeck dan pengurangan kekonduksian haba.

Kata kunci: Ni-dop; pengaloian mekanikal; skuterudit; termoelektrik

RUJUKAN

Bashir, M.B.A., Said, S.M., Sabri, M.F.M., Shnawah, D.A. & Elsheikh, M.H. 2014. Recent advances on Mg 2 Si_1-x Sn x materials for thermoelectric generation. Renewable and Sustainable Energy Reviews 37: 569-584.

Da Ros, V., Masschelein, P., Candolfi, C., Leszczynski, J., Kosalathip, V., Dauscher, A., Lenoir, B., Stiewe, C. & Müller, E. 2007. Effect of the Ni substitution on CoSb3 partially filled with In and Yb. Paper presented at the 5th European Conference on Thermoelectrics, Odessa, Ukraine.

Elsheikh, M.H., Sabri, M.F.M., Said, S.M., Miyazaki, Y., Masjuki, H., Shnawah, D.A., Abdullah, N., Naito, S. & Bashir, M.B.A. 2016. Microstructural modification of Co₄Sb₁₂ skutterudite thermoelectric material through al exceed doping. Science of Advanced Materials 8(11): 2121-2127.

Elsheikh, M.H., Sabri, M.F.M., Said, S.M., Miyazaki, Y., Masjuki, H., Shnawah, D.A., Naito, S. & Bashir, M.B.A. 2017. Rapid preparation of bulk AlxYb_0.25Co₄Sb₁₂ (x= 0, 0.1, 0.2, 0.3) skutterudite thermoelectric materials with high figure of merit ZT= 1.36. Journal of Materials Science 52(9): 5324-5332.

Elsheikh, M.H., Shnawah, D.A., Sabri, M.F.M., Said, S.B.M., Hassan, M.H., Bashir, M.B.A. & Mohamad, M. 2014. A review on thermoelectric renewable energy: Principle parameters that affect their performance. Renewable and Sustainable Energy Reviews 30: 337-355.

Geng, H., Ochi, S. & Guo, J. 2007. Solidification contraction-free synthesis for the Yb_0.15 Co₄ Sb₁₂ bulk material. Applied Physics Letters 91(2): 022106.

Il-Ho, K.I.M., Kwan-Ho, P., Soon-Chul, U., Soon-Mok, C. & Won-Seon, S. 2010. Transport properties of Sn-doped CoSb_3 skutterudites. Journal of the Korean Physical Society 57(41): 1000.

Kawaharada, Y., Kurosaki, K., Uno, M. & Yamanaka, S. 2001. Thermoelectric properties of CoSb3. Journal of Alloys and Compounds 315(1): 193-197.

Park, K.H., Kim, I.H., Choi, S.M., Seo, W.S., Cheong, D.I. & Kang, H. 2012. Preparation and thermoelectric properties of p-Type Yb-filled skutterudites. Journal of Electronic Materials 42(7): 1377-1381.

Park, K.H., Seo, W.S., Shin, D.K. & Kim, I.H. 2014. Thermoelectric properties of Yb-filled CoSb3 skutterudites. Journal of the Korean Physical Society 65(4): 491-495.

Peng, J., Yang, J., Song, X., Chen, Y. & Zhang, T. 2006. Effect of Fe substitution on the thermoelectric transport properties of CoSb 3-based Skutterudite compound. Journal of Alloys and Compounds 426(1): 7-11.

Said, S.M., Bashir, M.B.A., Sabri, M.F.M., Miyazaki, Y., Shnawah, D.A.A., Hakeem, A.S., Shimada, M., Bakare, A.I., Nik Ghazali, N.N. & Elsheikh, M.H. 2017. Enhancement of thermoelectric behavior of La_0.5Co₄Sb_12−xTex skutterudite materials. Metallurgical and Materials Transactions A 48(6): 3073-3081.

Takizawa, H., Miura, K., Ito, M., Suzuki, T. & Endo, T. 1999. Atom insertion into the CoSb3 skutterudite host lattice under high pressure. Journal of Alloys and Compounds 282(1-2): 79-83.

Tritt, T.M., Nolas, G., Slack, G., Ehrlich, A., Gillespie, D. & Cohn, J.L. 1996. Low-temperature transport properties of the filled and unfilled IrSb3 skutterudite system. Journal of Applied Physics 79(11): 8412-8418.

Truong, D.N., Kleinke, H. & Gascoin, F. 2014. Thermoelectric properties of higher manganese silicide/multi-walled carbon nanotube composites. Dalton Transactions 43: 15092-15097.

Yang, J., Chen, Y., Zhu, W., Peng, J., Bao, S., Fan, X.A. & Duan, X.K. 2006. Effect of La filling on thermoelectric properties of LaxCo_3.6Ni_0.4Sb12-filled skutterudite prepared by MA–HP method. Journal of Solid State Chemistry 179(1): 212-216.

Zhang, J., Lu, Q., Liu, K., Zhang, L. & Zhou, M. 2004. Synthesis and thermoelectric properties of CoSb₃ compounds by spark plasma sintering. Materials Letters 58(14): 1981-1984.

*Pengarang untuk surat-menyurat; email: smsaid@um.edu.my